By Jeff Woodard on Friday, November 09, 2001 - 03:41 pm: Edit

I just picked up a set of 4000s and a (used?) wiring harness. No instructions, of course, and nothing on Hella's website. Can anyone clue me in on the proper way to wire them up? Much appreciated!
Jeff
[email protected]

By Phillip Perkinson (R0ver4x4) on Friday, November 09, 2001 - 03:48 pm: Edit

there is something about lights in the tech section of this site and all go to D-90.com and look at the technical section there......good luck..or go to autozone or something like that and get a set of hellas and look at the wiring diagram then take the lights back.have done it before keep your recept

By marty amedeo (Marty) on Friday, November 09, 2001 - 06:03 pm: Edit

Best thing to do is buy the wiring harness from Hella, it has everything you need to get them working. Also, a suggestion, wire them so they only light when your hi-beams are on, that way they go off when you dim your hi-beams for oncoming traffic.

By Craig on Friday, November 09, 2001 - 08:50 pm: Edit

Jeff-
Hella has a specific harness for those lights. hella part number 87202. You can pick one up at Pep Boys.
Craig

By Jeff Woodard on Friday, November 09, 2001 - 08:42 pm: Edit

Thanks for the suggestions so far. The wiring harness I have is from Hella, part #87199U. It's not clear to me what needs to route where, though. I'll check out the D-90 site, but welcome all further comments.
Jeff

By marty amedeo (Marty) on Saturday, November 10, 2001 - 01:43 am: Edit

Jeff

As Craig said, the part number forthe 4000 harness is 87202, I'm not that familiar with Hella's harness's to say if the one you have will do the job.

If you go to Hella's website, www.hellausa, click on the installation intructions for the Optilux 1100 lamps and this will show you the wiring arrangement you need to install.

Marty

By Warren on Saturday, November 10, 2001 - 12:53 pm: Edit

I'm getting 4 roof rack mounted Hella 4,000's are the 4,000 wiring harness long enough to reach the battery and relays?

By Danno on Saturday, November 10, 2001 - 06:37 pm: Edit

From the Relay
RED to the Battery
Brown to Ground
Green to switch then headlight/parking light for feed.
Blue to 4000's

From the 400
Yellow to the Headlight bulb
BROWN to Ground
BLUE to Relay

By Danno on Saturday, November 10, 2001 - 06:41 pm: Edit

BTW i wired the GREEN wire to my city light connection so that my lights work with parking only, low and high beams.

By Danno on Saturday, November 10, 2001 - 06:47 pm: Edit

the yellow wire is for the 4000's with the City (parking) light. i don't think that i have it connected to anything.