Question w/ Sunroof

[vaden87]

1997 Discovery SE7

My front sunroof stopped working in the fall, and its getting warm again, so I want it back!

The passenger side track seems broken or something. It wont completely work on its own. When trying to open it, if you push it a little bit, it will catch and then go on its own. But sometimes one side goes faster than the other and it gets wedged.

When shutting it, it will sometimes go most the way with no help. When it gets to the "pulling glass down and sealing" part, it dont.

QUESTION #1: Is it just the track that needs fixing?

QUESTION #2: Where can I buy just the track?

Thanks!


-Ryan

 

[Chris-St Louis]

1 of 6 TSBs that Rover had on sunroofs.

In some cases the sunroof mechanisms on Discovery jam during tilt operation. A new sunroof assembly ha been developed to address this problem. The following procedure should be used to replace the sunroof assemblies.

If sunroof replacement is required, note the following:

^ Both front and rear sunroof assemblies are to be replaced at the same time even if only one has jammed.

^ Only complete assemblies should be installed to affect repairs.


Before you start this repair, the technician should take time to test the various systems that might be affected by this operation. Also, cleanliness is very important; it only takes a small smudge to ruin the customer's opinion of an otherwise good job. Any problems found during this inspection should be brought to the service manager's attention.

The diagnostic steps and repair procedures detailed on the following pages were developed as an element of the Land Rover Way OPERATION PRIDE. This TIB provides a library location for PRIDE information within the Land Rover North America technical literature system.

ACTION REQUIRED

Upon customer complaint for the symptoms outlined, perform the specified repairs.

PARTS INFORMATION

BTR8240 - Sunroof Assembly

 

[Chris-St Louis]

Another one.

* Sunroof Open Position Rattle or Jam *

AFFECTED VEHICLE RANGE:

DISCOVERY (U) Up to VA746176

SITUATION;

SUNROOF RATTLES IN TILT OR FULLY OPEN POSITION

Owners may experience raffles from the sunroof area when driving on rough pavement or uneven surfaces. The cause may be the sunroof mechanism or a loose sunroof glass. Possible flexing of the roof panel stiffeners may contribute to the sunroof rattle.
* Some early sunroofs may also experience jamming during tilt operations. *

RESOLUTION:

DETERMINE SOURCE OF RATTLE AND CORRECT, REPAIR JAMMED MECHANISM

NOTE :Only the sunroof diagnosed with a rattle during a test drive should be repaired. It is not necessary to rework both sunroofs in all cases.

To resolve an owner complaint of sunroof rattle, inspect sunroof area and perform test drive to determine source of rattles. When rattle source has been identified, perform corrective procedure.

* Sunroofs which jam during the tilting operation may be repaired using the guide rails announced in this bulletin. *

PARTS INFORMATION:

* CAUTION : It is important to identify the clamping/lower frame assembly installed in the vehicle to ensure that only the latest configuration is used with the new guide rails. *

EGM 100190 Sunroof guide rail kit (Includes LH and RH rail
for one sunroof assembly)

* STC 1686 Lower Frame Assembly (Required for clearance when rails are
replaced on original sunroof assembly used up to VINs
TA188273 and TA519024) *

Locally sourced:

^ Polyurethane Sealer (Example: Sikaflex 221 or Betafill 10215)


WARRANTY CLAIMS:

76.82.89/35 4.15 hrs.
Apply sealer to roof stiffeners and fit one guide rail kit.

COMP CODE 9D5K for front sunroof
9S5K for rear sunroof

76.82.89/38 4.65 hrs.
Apply sealer to roof stiffeners and fit two guide rail kits.

COMP CODE 9D5K

* Normal warranty policy and procedures apply (See Policy Statement which follows.) *

* POLICY STATEMENT:
THIS TIB SUPERSEDED AND REPLACES ALL PREVIOUSLY PUBLISHED TIBS RELATING TO DISCOVERY SUNROOF JAMMING OR RATTLE.

^ Only the sunroof diagnosed as jammed or exhibiting a rattle during a test drive is to be repaired. It is not necessary to rework both sunroofs in all cases.

^ Sunroof replacement is no longer authorized as a sunroof rattle or jamming repair.

^ Warranty claims for replacement of sunroofs to correct jammed or rattling conditions will be denied if the repair date is after 17 November 1997.

^ Vehicles prior to VINs TA188273 and TA519024 may still be equipped with the original specification sunroof clamping/lower fram assembly (without relief impressions for the rails). The replacement of the clamping/lower frame assembly is authorized to replace the early design in conjunction with the fitting of the side rail kit. *

 

[Billy Breathes]

ryan, what's up? this is nick.

 

[DiscoJen]

Try here for the tracks

QUESTION #2: Where can I buy just the track?

Motorcars LTD in Texas started selling a kit to replace the tracks. Give Gallagher a call and he should have the info you need. Tell him Jen sent ya.

Jen

 

[Errant]

I've just started having the same problem with the rear sunroof on my '98. I'll try cleaning and lubing the rails this weekend (once I find a way to climb up there), and if that doesn't do it I'll end up ordering the kit from Motorcars LTD (but I'm scared!).

 

[vaden87]

hey nick, snazzy id